Aplikasi Membran Filter Keramik Untuk Menurunkan Konsentrasi Zat Warna Remazol Red dan Nilai COD Limbah Cair Batik

Nur Fitriana, Maya Rahmayanti

Abstract


Research on the application of ceramic filter membranes in reducing remazol red dye concentration and COD value of batik liquid waste has been carried out. The purpose of this study was to reduce the remazol red dye concentration and the COD value of batik wastewater using a ceramic filter membrane. The ceramic filter membrane used was made from clay and silica sand with variations in the number of additions of wood sawdust as much as 0, 1, 3, 5 and 7%. Then the porosity of the ceramic filter membrane was tested to determine the percentage of the pore volume that the ceramic filter membrane had. The ceramic filter membrane with the composition of clay, silica sand and 1% wood sawdust was the most optimum in reducing remazol red dye up to 86.68% and reducing COD value up to 97.87%.

 

Keywords: filtration, remazol red, COD, ceramic filter membranes, batik liquid waste

 


Full Text:

PDF

References


Agmalini, Lingga, dan Nasir. 2013. Peningkatan Kualitas Air Rawa Menggunakan Membran Keramik Berbahan Tanah Liat Alam dan Abu Terbang Batubara. Journal Teknik Kimia, 10 (2).

Amin, M. dan Irawan, B. 2008. Pengaruh Tekanan Kompaksi Terhadap Karakterisasi Keramik Kaolin Yang Dibuat Dengan Proses Pressureless Sintering. Traksi. 8(1): 40-54.

Ekowati, G. W. dan Rahmayanti, M. 2019. Kajian Desorpsi Zat Warna Indigosol Blue Dari Adsorben Humin Hasil Isolasi Tanah Gambut Riau, Sumatera, Analit: Analytical and Environmental Chemistry, 4(2), 68-75.

Fuadah, S.R. dan Rahmayanti, M. 2019. Adsorpsi-Desorpsi Zat Warna Naftol Blue Black Menggunakan Adsorben Humin Hasil Isolasi Tanah Gambut Riau, Sumatera. Analit: Analytical and Environmental Chemistry, 4(2), 59-67.

Hubaidillah, Othman, Tai, Jamalludin, Yusuf, Ahmad, Rahman, Jaafar, Kadir, dan Harun. 2020. Novel Hydroxyapatite-Based Bio-Ceramic Hollow fiber Membrane Derived from Waste Cow Bone for Textile Wastewater Treatment. Joural Chemical Engineering Journal (2020) 122396.

Latifah, W.N. dan Rahmayanti, M. 2020. Desorption of Indigosol Blue from Humic Acid Coated Fe3O4 Particles, in Proceeding International Conference Science and Engineering 3, 169-170.

Murniati, Tri dan Muljadi. 2013. Pengolahan Limbah Batik Cetak Dengan Menggunakan Metode Filtrasi-Elektrolisis Untuk Menentukan Efisiensi Penurunan Parameter COD, BOD, dan Logam Berat (Cr) Setelah Perlakuan Fisika-Kimia. Jurnal Ekuilibrum, 12(1), 27-36.

Nainggolan, Purluhutan Ricardo. 2015. Pengendalian Fouling pada Sistem Pengolahan Air Berbasis Membran. Bandung: Jurusan Teknik Kimia, Fakultas Teknologi Industri, Institut Teknologi Bandung.

Prameswari, Tania. 2013. Sintesis Membran Kitosan-Silika Abu Sekam Padi untuk Dekolorisaso Zat Warna Congo Red. Semarang; Universitas Negeri Semarang.

Prandini, M. N.dan Rahmayanti, M. 2020. Effect pH Adsorption of Naphtol Dye Using Humic Acid Adsorbent Result of Peat Isolation from Kalimantan, in Proceeding International Conference Science and Engineering 3, 147-151.

Rahmayanti, M., Yunita, E., dan Putri, N. F. Y. 2020. Study of Adsorption-Desorption on Batik Industrial Dyes (Naphthol Blue Black) on Magnetite Modified Humic Acid (HA-Fe3O4), Jurnal Kimia Sains dan Aplikasi, 23(7), 244-248.

Santi G.C. dan Rahmayanti, M. 2019. Effect of Solution pH to Indigosol Blue Adsorption on Humic Acid Isolated from Kalimantan Peat Oil, in Proceeding International Conference Science and Engineering 2, 193-195.

Tolba, Bastaweesy, Ashour, Abdelmoez, Khalil dan Barakat. 2016. Effective and Highly Recyclable Ceramic Membane Based on Amorphous Nanosilica for Dye Removal from The Aqueous Solutions. Arabian Journal of Chemistry. King Saud University:

Wahyuni, Anis Tri. 2014. Sintesis Biosorben Dari Limbah Kayu Jati dan Aplikasinya Untuk Menjerap Logam Pb Dalam Limbah Cair Artifisial. Skripsi. Universitas Negeri Semarang.

Wenten, I.G, Hakim, Khoirudin dan Aryanti. 2013. Polarisasi Konsentrasi dan Fouling pada Membran. Bandung: Institut Teknik Bandung.




DOI: https://doi.org/10.24252/al-kimia.v8i2.15932

Refbacks

  • There are currently no refbacks.


Al-Kimia has been indexed in :

See Google Scholar Profile for Al-Kimia by clicking here.

       

More...

Supported By:

Creative Commons License All Publication by Al-Kimia are licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

Visitor Number: StatCounter - Free Web Tracker and Counter View Al-Kimia Stats

________________________________________________
Al-Kimia, p-ISSN : 2302-2736, e-ISSN : 2549-9335

Office Address:

Faculty of Science and Technology, Universitas Islam Negeri Alauddin Makassar, Indonesia
Jl. H. M. Yasin Limpo No. 36 Samata, Gowa, Sulawesi Selatan

Contact Person: +6285-286-545-307,

Email: al-kimia@uin-alauddin.ac.id